![]() |
|
Welcome to the Australian Ford Forums forum. You are currently viewing our boards as a guest which gives you limited access to view most discussions and inserts advertising. By joining our free community you will have access to post topics, communicate privately with other members, respond to polls, upload content and access many other special features without post based advertising banners. Registration is simple and absolutely free so please, join our community today! If you have any problems with the registration process or your account login, please contact us. Please Note: All new registrations go through a manual approval queue to keep spammers out. This is checked twice each day so there will be a delay before your registration is activated. |
|
![]() |
|
Thread Tools | Display Modes |
![]() |
#1 | ||
Regular Member
Join Date: Feb 2016
Location: Goulburn NSW
Posts: 316
|
Hi all,
Had an issue xmas eve with my Mondeo stalling shortly after starting, then winding over for 30 seconds or so before starting, then stalling again. Didn't have time to muck with it, so took the wife's car instead. Finally got a chance to look this afternoon, and it started after 30 seconds of winding, then missed a little then cleared. Before i started it there appeared to be air in the fuel line after the filter, and obvious bubbles of air when it was missing. Bubbles cleared out and it seems to be running fine now (haven't driven it though) Any thoughts. Fuel filter has done around 22K km, i usually change it at 30K. Tank is over 1/4 full so i don't think it's that. Planning on replacing the filter tomorrow, then taking it for a run.
__________________
2012 MC Mondeo LX TDCi Wagon - Highway Hack 392K km and counting - Now gone 😢 2008 Peugeot 308 HDi - Highway Hack II 2008 Citroen C4 HDi - Highway Hack III 2010 Peugeot 308 HDi SW - Shaggin Wagon II 2016 VDJ200R Landcruiser GX Wagon - TTD V8 Power ![]() 2017 Toyota RAV4 GX Wagon - Shopping trolley - Gone 2022 Volvo XC40 T4 Inscription - Shopping trolley II 2002 BMW R1150GS |
||
![]() |
![]() ![]() |
![]() |
#2 | ||
FF.Com.Au Hardcore
Join Date: Mar 2013
Posts: 7,645
|
Bad fuel maybe? Did this happen not long after fueling up?
|
||
![]() |
![]() ![]() |
![]() |
#3 | ||
Regular Member
Join Date: Feb 2016
Location: Goulburn NSW
Posts: 316
|
No, about 800km after refilling.
My wife was the last to drive it, and she has a tendency to drive too fast up our rough gravel driveway. I thought maybe she shook some air bubbles into the system but it had sat overnight before trying to start the first time.
__________________
2012 MC Mondeo LX TDCi Wagon - Highway Hack 392K km and counting - Now gone 😢 2008 Peugeot 308 HDi - Highway Hack II 2008 Citroen C4 HDi - Highway Hack III 2010 Peugeot 308 HDi SW - Shaggin Wagon II 2016 VDJ200R Landcruiser GX Wagon - TTD V8 Power ![]() 2017 Toyota RAV4 GX Wagon - Shopping trolley - Gone 2022 Volvo XC40 T4 Inscription - Shopping trolley II 2002 BMW R1150GS |
||
![]() |
![]() ![]() |
![]() |
#4 | ||
FF.Com.Au Hardcore
Join Date: Mar 2013
Posts: 7,645
|
Shaking as such would not do it, but if your on a 1/4 tank and the driveway is steep, the fuel can move away from the pick up and then it might suck up some air?
|
||
![]() |
![]() ![]() |
![]() |
#5 | ||
Regular Member
Join Date: Feb 2016
Location: Goulburn NSW
Posts: 316
|
Fingers crossed this is the cause. Driveway is quite steep, and very rough at the moment. I'll change the filter today and see if that helps. I do around 1500km a week in this car so reliability is a must.
__________________
2012 MC Mondeo LX TDCi Wagon - Highway Hack 392K km and counting - Now gone 😢 2008 Peugeot 308 HDi - Highway Hack II 2008 Citroen C4 HDi - Highway Hack III 2010 Peugeot 308 HDi SW - Shaggin Wagon II 2016 VDJ200R Landcruiser GX Wagon - TTD V8 Power ![]() 2017 Toyota RAV4 GX Wagon - Shopping trolley - Gone 2022 Volvo XC40 T4 Inscription - Shopping trolley II 2002 BMW R1150GS |
||
![]() |
![]() ![]() |
![]() |
#6 | ||
Regular Member
Join Date: Feb 2016
Location: Goulburn NSW
Posts: 316
|
No further issues. Im going to put it down to the cooks rough driving.......
__________________
2012 MC Mondeo LX TDCi Wagon - Highway Hack 392K km and counting - Now gone 😢 2008 Peugeot 308 HDi - Highway Hack II 2008 Citroen C4 HDi - Highway Hack III 2010 Peugeot 308 HDi SW - Shaggin Wagon II 2016 VDJ200R Landcruiser GX Wagon - TTD V8 Power ![]() 2017 Toyota RAV4 GX Wagon - Shopping trolley - Gone 2022 Volvo XC40 T4 Inscription - Shopping trolley II 2002 BMW R1150GS |
||
![]() |
![]() ![]() |
![]() |
#7 | ||
Regular Member
Join Date: Feb 2016
Location: Goulburn NSW
Posts: 316
|
Same issue today. Very low fuel level, and steep rough driveway. Misfired a few times on the way to town this morning, and threw an Engine Malfunction warning.
Put 69.9L in it and CEL cleared upon restart. Must not try to drive home and back with the fuel light on (45km round trip)
__________________
2012 MC Mondeo LX TDCi Wagon - Highway Hack 392K km and counting - Now gone 😢 2008 Peugeot 308 HDi - Highway Hack II 2008 Citroen C4 HDi - Highway Hack III 2010 Peugeot 308 HDi SW - Shaggin Wagon II 2016 VDJ200R Landcruiser GX Wagon - TTD V8 Power ![]() 2017 Toyota RAV4 GX Wagon - Shopping trolley - Gone 2022 Volvo XC40 T4 Inscription - Shopping trolley II 2002 BMW R1150GS |
||
![]() |
![]() ![]() |
This user likes this post: |
![]() |
#8 | ||
Starter Motor
Join Date: Jan 2020
Posts: 1
|
A similar thing happened in my 2011 MC Mondeo. Engine would stall while driving and it progressively got worse until eventually I couldn’t start the car. Check with scanner showed a few messages including both low and high fuel pressure messages.
Turns out it was the high pressure fuel sensor in the fuel rail. Could be a different issue but worth ruling out. Got a second hand sensor one from the wreckers for $100 and it fixed the issue for me. |
||
![]() |
![]() ![]() |